What is the max HP of K04 23?
We have provided the K04-023 turbocharger with a upgrade, so you can drive with our turbocharger up to 330 HP. So that this also holds at higher loads, the turbo is equipped with a reinforced support. Original 023 turbochargers can be loaded up to a maximum of 260 HP, after that the wear is increased significantly. At sea-level, air is about 14. PSI. Adding 5 PSI of boost to atmospheric 14. PSI, you get about a 34% increase in oxygen (19. PSI vs 14. PSI), or you would do roughly 260 HP in an engine that made 200 HP beforehand.A turbocharger may typically increase an engine’s horsepower by anywhere between 40 and 300 horsepower. However, the exact number is difficult to tell as the quality of collaboration of different parts always influences the overall improvement.The maximum pressure ratio of common turbochargers ranges from as low as 2, to as high as 5 or 6. At sea level these pressure ratios range from 15 psi to 75psi of boost, so 30 to 90psi absolute.More air pressure (or boost) means more oxygen and more oxygen means more power and of course, more power equals more burnouts. Play Video about Turbosmart Knows Boost – How do Forced induction Engines Work?
How much horsepower does a K04 add?
The K04 turbocharger is a great turbocharger for the Gen 2 TSI engine. It delivers 330-350 horsepower which is a good, reliable amount on the stock engine. While turbos are rigorously stress-tested, and should last the lifetime of the engine, regular bouts of aggressive driving could take their toll, and cause costly issues. And remember – not only will gentle cruising spare your turbo, it’ll give you great fuel economy, too.On average, turbos last up to 150,000 miles. But with good care, they may last up to 200,000 miles or have a life expectancy of 30 years. To get one thing clear, it will take you about two decades until you need to replace your turbocharger, even if you regularly drive your vehicle.If you select a turbo that’s too big for your application you will experience turbo lag. Inversely if the turbo is too small you risk not reaching your horsepower target, as well as increasing your risk of over speeding the turbo, which leads to turbo failure and possible costly engine damage.Increased Power: Turbo engines can produce a lot more power relative to their size, which is perfect for overtaking on the motorways. Fuel Efficiency: A small turbocharged engine can deliver decent fuel economy while providing power on demand. Fun to Drive: Turbo engines deliver a thrilling, sporty experience.The turbocharger is what makes an I4 engine truly stand out. It works by forcing exhaust back into the cylinders, which creates bigger explosions as the pistons pump air into the cylinders. The result is more power and higher horsepower in larger engines that can outrun comparable V6 engines.
What is the APR K04 turbo upgrade?
The APR K04 Turbocharger System is a drop in turbo upgrade that dramatically increases power. With this upgrade and accompanying software, expect power similar to a heavily tuned Golf R, S3, TT-S, and other high end vehicles, as the K04 comes standard on those vehicles. A turbocharger also reduces the exhaust noise by using some of the exhaust gases to power the turbine. This means that there is less pressure and volume of exhaust gases that go through the exhaust system, and therefore less noise.Another disadvantage is reliability. When you add a turbocharger to the engine, you are adding another layer of mechanical complexity to just an ordinary engine. So more things can go wrong, thus it requires maintenance more often. And subsequently make the turbocharger engine more expensive.That said, because superchargers do depend on the running engine to operate, it’s a less efficient process than a turbocharger. They are also, on the whole, more expensive than a turbocharger, but they’re also easier to install.Powerful Power Boost: Hosepower: Up to 400+HP, the turbocharger provides a powerful boost to your vehicle’s power.
What Audi has a KO4 turbo?
Cts turbo is proud to announce an official release of our new k04 turbocharger upgrade for b7, b8 and b8. Audi a4/a5/allroad/q5 2. T cars. This unit features a full-frame k04 chra installed into our proprietary, in-house designed compressor cover and turbine housing. K03 ko3 replacement turbocharger turbo 1. L for vw volkswagen passat and audi a4. This k03 turbocharger is a direct replacement for the original turbo found on the 1996-2004 audi a4 and 1998-2005 volkswagen passat 1. T engines. This turbocharger is not meant as an upgrade for the factory unit.